Floods in southwest China kill 14

Firefighters work in a flooded street Monday in Wangmo county, Guizhou province, China.The floods triggered by heavy rains are affecting southwest ChinaAt least 45,000 residents in one hard-hit county evacuate

Beijing (CNN) -- Floods that have ravaged parts of China have left 14 people dead and 53 people missing, government officials said Tuesday.

The floods have hit parts of Guizhou province in southwest China affecting 14 cities damaging thousands of homes, the Ministry of Civil Affairs said.

The floods triggered by heavy rains have caused at least 45,000 residents in one hard-hit county to evacuate, Xinhua news agency reported.

CNN

Air Force checking its 737s in wake of Southwest incident

By Larry Shaughnessy, CNN STORY HIGHLIGHTSThe Air Force has two Boeing 737sThey are used for VIP flightsPlanes have been checked to make sure they are in good condition, spokeswoman says Washington (CNN) -- The U.S. Air Force says the military versions of the Boeing 737 that are used for VIP flights have been re-inspected after part of the ceiling of a similar type of Southwest Airlines plane ripped off in flight, allowing passengers to see the sky and forcing the pilots to make an emergency landing.

The Air Force only flies two 737s. They are based at Andrews Air Force Base near Washington and are for use by distinguished passengers like the first lady, the vice president, the secretary of state or congressional leaders, according to Maj. Shelley Lai, a spokeswoman for the 89th Airlift Wing at Andrews.

The Air Force's jets are the 737-700 model, which is much newer than the 737-300 model that was involved in the Southwest Airlines incident. Plus the Air Force's jets have seen far fewer "cycles" than the typical commercial Boeing 737. Those jets have gone through, on average, 35,000 take off and landing cycles. The Air Force's jets each have about 2,000 cycles. Take offs and landings put the most strain on an airplane, which is why number of cycles is a more important gauge of wear and tear on a plane than hours in flight or miles flown.

In spite of the differences between the jet involved in the Southwest case and the Air Force's jets, Lai said the Air Force did check to make sure it's planes are in good condition and it is in touch with Boeing, the FAA and the National Transportation Safety Board to make sure it is in compliance with all inspection and maintenance orders regarding 737s,

No Air Force flights have been delayed or canceled because of the problem with some commercial 737s.

View the Original article

Southwest grounds 2 more jets over cracks

By Jewel Samad, AFP/Getty Images

The 5-foot-long fuselage skin taken from the Southwest Airlines accident aircraft is shown at the National Transportation Safety Board in Washington, April 5.

EnlargeCloseBy Jewel Samad, AFP/Getty Images

The 5-foot-long fuselage skin taken from the Southwest Airlines accident aircraft is shown at the National Transportation Safety Board in Washington, April 5.

The airline said it discovered "minor subsurface cracking" on the aluminum skin on the Boeing 737-300s. The five jets have been taken out of service until Boeing can recommend how to repair them.

METAL FATIGUE: Experts say it is a rare riskAfter a weekend in which hundreds of its flights were canceled while the airline conducted inspections, Southwest said it has resumed normal service.

The inspections were triggered by an incident on Southwest Flight 812 from Phoenix to Sacramento. A 5-foot-long section of the aircraft's skin on the fuselage above the wing ripped open at 34,000 feet.

The sudden loss of cabin pressure forced the pilots to don oxygen masks and rapidly descend to lower altitudes. One flight attendant was injured, but none of the 118 passengers was hurt.

Investigators with the National Transportation Safety Board found a number of cracks on a line of rivets where two sections of the fuselage skin were connected. Those cracks appear to have weakened the skin, said NTSB board member Robert Sumwalt.

The discovery prompted the Federal Aviation Administration (FAA) and Boeing to require inspections on a small portion of the 737 fleet manufactured during the 1980s and 1990s. Out of the 80 such planes operated in the United States, Southwest owns 78. Alaska Airlines flies the other two.

NTSB Chairman Debbie Hersman said she was "very pleased" by the rapid response to the incident by Southwest, Boeing and the FAA.

The agency displayed the section of torn fuselage at its Washington, D.C., metals lab Tuesday. The jet's skin tore along a line of rivets that ran from the front to the rear of the jet, leaving a jagged edge flapping loose above the upper fuselage.

Southwest completed inspections of the 737-300s covered by the FAA before the agency could issue the formal order. "With our knowledge of what the FAA had planned, we believe the

View the Original article

NTSB: Cracks found in 3 grounded Southwest planes

officials said.

"What we saw with Flight 812 was a new and unknown issue," said Mike Van de Ven, Southwest executive vice president and chief operating officer. He said the airline had complied with federally mandated and Boeing-recommended inspections for the plane.

Federal records show cracks were found and repaired a year ago in the frame of the same Southwest plane.

A March 2010 inspection found 10 instances of cracking in the frame, which is part of the fuselage, and another 11 instances of cracked stringer clips, which help hold the plane's skin on, according to an AP review of FAA records of maintenance problems.

The records for the plane show the cracks were either repaired or the damaged parts replaced. Cracking accounted for a majority of the 28 problem reports filed as a result of that inspection.

It's common for fuselage cracks to be found during inspections of aging planes, especially during scheduled heavy-maintenance checks in which planes are taken apart so that inspectors can see into areas not normally visible.

The Arizona jetliner had gone through about 39,000 cycles of pressurizing, generally a count of takeoffs and landings. Cracks can develop from the constant cycle of pressurizing for flight, then releasing the pressure.

Southwest officials said the plane was given a routine inspection Tuesday and underwent its last so-called heavy check, a more costly and extensive overhaul, in March 2010.

The decompression happened about 18 minutes after takeoff from Phoenix Sky Harbor International Airport.

At cruising altitude of some 34,000 feet, the pilots declared an emergency and briefly considered returning to Phoenix before the cabin crew told them of the extent of the damage, Sumwalt said. The plane's voice and data recorders were being examined in Washington.

Southwest operates about 170 of the 737-300s in its fleet of 548 planes, but it replaced the aluminum skin on many of the 300s in recent years, a spokeswoman said. The planes that were grounded over the weekend have not had their skin replaced.

US Airways operates 18 of the older-model 737-300s, but the company said Monday it has been told by Boeing that its jets aren't affected.

Lufthansa has a fleet of 63 Boeing 737s, including 33 of the 300 series. But just three of those are from the same series as the Southwest jet.

"As a precautionary measure, all three aircraft underwent additional checks over the weekend, which didn't yield any further findings. Accordingly, the aircraft are operating as scheduled," said airline spokesman Martin Riecken. "We are in close contact with Boeing regarding this issue and are awaiting further advice from the manufacturer."

In July 2009, a football-sized hole opened up in-flight in the fuselage of another of Southwest's Boeing 737s, depressurizing the cabin. Sumwalt said the two incidents appeared to be unrelated.

A fuselage failure, although extremely rare, can have deadly consequences. In 1988, cracks caused part of the roof of an Aloha Airlines Boeing 737 to peel open while the jet flew from Hilo to Honolulu. The flight attendant died, and dozens of passengers were injured.

Copyright 2011 The Associated Press. All rights reserved. This material may not be published, broadcast, rewritten or redistributed.

For more information about reprints & permissions, visit our FAQ's. To report corrections and clarifications, contact Standards Editor Brent Jones. For publication consideration in the newspaper, send comments to letters

View the Original article

Southwest Has History of Triggering FAA Action

"Members of the National Transportation and Safety Board investigating the emergency landing of Southwest Airlines flight 812, carry a portion of the planes fuselage to a waiting vehicle on April 3 in Yuma, Ariz." /

View the Original article

NTSB: Cracks found in 3 grounded Southwest planes

By Nick Oza, The Arizona Republic via AP

Officials discovered cracks in more Southwest jeltiners, and the airline company grounded flights Monday for inspections.

EnlargeCloseBy Nick Oza, The Arizona Republic via AP

Officials discovered cracks in more Southwest jeltiners, and the airline company grounded flights Monday for inspections.

Boeing said Monday that it will issue guidance this week on how airlines should do checks on the affected airplanes now in service.

The 5-foot-long hole tore open Friday in the passenger cabin roof shortly after the Southwest plane carrying 118 people left Phoenix for Sacramento It made a rapid descent, landing at a military base in Yuma, 150 miles southwest of Phoenix. No one was seriously hurt.

Since then, Southwest grounded 79 other Boeing 737-300s and began inspecting them. The grounding caused about 600 flight cancellations over the weekend and another 70 on Monday. Nineteen inspected aircraft showed no problems and will be returned to service.

Checks on the remaining jets are expected to be completed by late Tuesday, the airline said.

READ MORE: Cracks found in Southwest aircraftThe incident raises new questions about the vulnerability of the nation's air fleet to fatigue cracks, more than two decades after cracks caused part of the roof of an Aloha Airlines Boeing 737 to peel open. A flight attendant was sucked out and plunged to her death.

There are 931 737-300 such models in service worldwide, 288 of which are in the U.S. fleet. Boeing said its service bulletin will also require checks on some 737-400 and 737-500 models as well, depending on how many pressurization cycles they have gone through.

The new inspection would be a one-time check, Boeing spokesman Marc Birtel said.

The "service bulletin" Boeing was developing will target all similar 737 models with comparable flight cycle time as the Arizona jet, which was 15 years old and had about 39,000 takeoff and landing cycles, National Transportation Safety Board member Robert Sumwalt said.

The bulletin would outline extensive checks of two lines of "lap joints" that run the length of the fuselage. The NTSB has not mandated the checks, but Sumwalt said the Federal Aviation Administration is likely to make them mandatory.

The NTSB also could issue urgent recommendations for inspections on other 737s if investigators decide a problem has been overlooked. The FAA declined to say if it would require other operators to check their aircraft for similar flaws.

The cracks found in the three Southwest planes developed in two lines of riveted joints that run the length of the aircraft. The agency is focusing its probe on the area of the cracks but has not determined that the cracks caused the rupture.

Two planes have been found with cracks similar to those in the Phoenix aircraft and will be evaluated and repaired before they are returned to service, Southwest said on Sunday in a prepared statement about its inspections. Sumwalt said a third plane had been found with cracks developing.

The NTSB planned a press briefing at 1:30 p.m. PT on Monday.

Previously, the riveted joints were not extensively checked because they were believed not susceptible to fatigue, Sumwalt said.

"Up to this point only visual inspections were required for 737s of this type because testing and analysis did not indicate that more extensive testing was necessary," Sumwalt said. That will likely change after Friday's incident, he said.

The tear along a riveted "lap joint" above the midsection of the plane shows evidence of extensive cracking that hadn't been discovered during routine maintenance

View the Original article

Southwest to cancel about 100 flights as inspections continue

Hole forces a Boeing 737 to landSTORY HIGHLIGHTSA hole opened on top of a Boeing 737 during flightDuring inspections, investigators find indications of cracks in three other aircraftThe inspections are expected to be complete on TuesdayBoeing declines to comment on the possible cause of the incident (CNN) -- Southwest Airlines expects to cancel about 100 flights from its Monday schedule as investigators continue inspecting its fleet, the airline said.

The Texas-based airline grounded 79 planes for inspection after a hole opened on top of a Boeing 737 mid-flight Friday.

It canceled approximately 600 flights to accommodate the inspections: 300 on Saturday and 300 flights on Sunday.

So far, investigators have found indications of cracks in three other aircraft, the National Transportation Safety Board said Sunday.

Of the planes inspected, 19 had returned to service by Sunday afternoon, the airline said.

View the Original article

Southwest grounds planes after roof rips open on 737

Updated

Share We've updated the Conversation Guidelines. Changes include a brief review of the moderation process and an explanation on how to use the "Report Abuse" button. Read more.

Advertisement

Most PopularStoriesSouthwest grounds planes after roof rips...Southwest flight makes emergency landing,...Georgia Aquarium opens elaborate new...Flight attendant helps land plane at ...Naked woman creates ruckus on Delta flight...VideosRapid decompression forces emergency landingRaw video: Dog rescued 3 weeks after Japan quakeLibyan rebels: NATO airstrike killed 13 rebelsMarines assist JapanUConn edges Kentucky to reach title gamePhotosCruise Ship ToursOddball cars from the Charlotte AutoFairSpring Break 2011Ritz-Carlton Hong Kong: The world's highest hotelCherry Blossoms in WashingtonMost Popular E-mail Newsletter

View the Original article

Southwest to ground 79 planes

Passengers describe emergency landingSTORY HIGHLIGHTSA 3- to 4-foot hole is discovered in a plane's fuselageFAA: The captain made a rapid descent from 36,000 feet to 11,000 feetPassengers arrive in Sacramento, California, on a second plane (CNN) -- Southwest Airlines announced Saturday that it is grounding 79 planes for inspection following an incident in which one of its flights was forced to make an emergency landing after a 3- to 4-foot hole tore open in the fuselage of the plane.

The plane -- which had been traveling from Phoenix to Sacramento, California -- managed to land safely at a military base in Yuma, Arizona, on Friday. There authorities "discovered a hole in the top of the aircraft," the company said earlier.

Investigators are trying to determine what caused the "depressurization event" and have "decided to keep a subset of its Boeing 737 fleet out of the flying schedule to begin an aggressive inspection effort in cooperation with Boeing engineers," according to a company statement.

"The safety of our customers and employees is our primary concern, and we are grateful there were no serious injuries," said Mike Van de Ven, Southwest's executive vice president and chief operating officer.

The airline initially reported that 81 of its Boeing 737 aircraft would be grounded, but later decreased the number of planes to be inspected for what it called "aircraft skin fatigue." The inspections will take place at five locations over the course of the next several days, the airline said.

Meanwhile, passengers who were aboard the crippled the Boeing 737 said they had feared for their lives.

View the Original article

Fuselage hole forces Southwest emergency landing

By Brenda Reese, AP

Passengers take photos with cell phones of an apparent hole in the cabin on a Southwest Airlines aircraft Friday.

EnlargeCloseBy Brenda Reese, AP

Passengers take photos with cell phones of an apparent hole in the cabin on a Southwest Airlines aircraft Friday.

Federal officials said it was a "fuselage rupture"

View the Original article